Dealer was unable to diagnose and resolve. If happens and driver is unaware until too late, entire inverter system could be ruined or possible battery fire. Recall date. We are ranked A+ by the BBB. When you need a completely rebuilt transfer case, you have the option of buying one from a junk dealer or getting something that will last for another 50,000 miles or more with no signs of problems. Recall date. Clunking from rear differential with the driver's side rear wheel turning only sporadically. Dealer has had my vehicle for a week not being able to reproduce event. Leaking appears to be coming from a white plastic block at the rear of the gas tank.. 1. The car is not drivable and hyundai is unwilling to replace the engine on a car with less than 8,000 miles on it. The seal and grease used between the Transfer case and the transmission is deficient. I am also told that this new unit will not be replaced under the power train warranty. The vehicle was towed to a local mechanic. all problems of the 2002 Hyundai Santa Fe It seems you have been given the run-around by the dealer and the company needs to know. When she uses a cushion the air bag off light goes on indicating she is not protected from collision. We dont sell units with leaking or blown gaskets. You need to have them inspect the master cylinder and the clutch to determine what the problem is. After two weeks and 1100 miles car started leaking gasoline on garage floor, street and driveway at rate of approx one drop every two seconds. Affordable and Dependable Transfer Cases and AWD Units. After two weeks and 1100 miles car started leaking gasoline on garage floor, street and driveway at rate of approx one drop every two seconds. statistics and reliability analysis of the 2012 Hyundai Santa Fe. Yesterday we were told by the dealer service manager that because we put 2 new tyres (the spare which had never been rotated and a new one to replace a faulty one), that because the rear were now 3/8ths WORN, that we were going to cause problems with the centre differential and that from now on our transmission is not warrantable. THERE IS A SIGNIFICANT AMOUNT OF FUEL IN THE OIL. I told him I have looked this up online and it has been an issue with other years of the santa fe. What you pay for is a completely rebuilt unit that is guaranteed to be ready for installation in your Santa Fe SUV. Not only is it not safe for my son and myself, but for other drivers around me as well. Our vehicle was completely dead with no dash lights, no infotainment screen, we could not put the car in park or drive. Asked by DarkCloudHangsOverMe. The contact stated that since purchasing the vehicle, the horn was inoperable. The contact had not experienced a failure. 32 parts and labor to correct an issue that is definitely a design flaw that occurred from Hyundai. The manufacturer was made aware of the failure. I was able to safely maintain control of the car, and pulled off at the next intersection. A final Edmunds review reads, The slower you go, the worse the suspension gets. Sometimes the Santa Fe wouldn't start. They have to drain the pan and drain the transmission to fix the faulty solenoid, so theyll have to refill it with new fluid and use a new gasket. I was operating the vehicle at a rate of 35-45 mph while getting on a highway ramp. There is no charge unless we win. With the vehicle jacked up and tires removed, I can actually hold the right read This is my latest issue with my 2012 Santa Fe (the previous being a bad transfer case which made it sputter, a bad 4wd coupling assembly which made it clunk while turning & a bad transmission range shaft which caused it to not start occasionally). The contact received notification of nhtsa campaign number: 22v746000 (power train) however, the part to do the recall repair was not yet available. The vehicle soon stalled and would not restart. Read more about the firm. The AWD system in my 2014 Hyundai Santa Fe failed leaving me with a big problem to get sorted. I told my husband earlier that day I heard the popping noise but did not see anything actually fly up and hit the windshield. . No codes in computer and unable to locate any recalls. I was able to find a vacuum in a short amount of time to clean out the shattered glass. The clutch would probably need to be replaced when the flywheel was changed as they are most likely to be different, but Hyundai should cop the cost. You will get them here but not anyplace else. Our Hyundai mechanics finish the rebuild and would put anything we have rebuilt up against a brand new Borg Warner 4424. I was traveling approximately 50 mph. Get back on the road and enjoy the ride. what? Worst 2015 Hyundai Santa Fe Problems #1: Transmission Pump Failure 2015 Santa Fe Average Cost to Fix: $2,500 Average Mileage: 74,000 mi #2: Steering Column Noise 2015 Santa Fe Average. Diesel Transmission Is the Hyundai Santa Fe 4 wheel drive or all wheel drive? Brian Jones spent more than 20 years working as an ASE Certified Master Tech and Parts Specialist at multiple dealerships. Parts distribution disconnect. Nice, clear day. I don't want this vehicle as I do not feel safe in it at all but the dealership says that there's no way to get out of this lease!. When I picked it up I asked them what do I do then they basically told me nothing and the service guy told me he didnt believe me. Message or call 877-795-3666 today. We were sitting in the travel lane of a very busy multi-lane roadway with no way to exit the vehicle unless we allowed it to become an errant vehicle. The contact owns a 2022 hyundai santa fe. Diff failures are not common, but not unknown either. Unsubscribe any time. Both times there was sufficient gas in the vehicle and it started right back up. They found that all of the splines on the output shaft had been worn down and were not meshing with the splines of the transfer case. We seek reimbursement for the repair and towing costs. We have a 2022 hyundai santa fe with less than 17,000 miles. Please advise. The contact owns a 2022 hyundai santa fe. The leak itself does not cause for concern but it can contaminate wirings, sensors etc. . If you are not sure whether your Hyundai Santa Fe AWD is working properly or not, then you should check the transmission. at first I didn't even realize what happened. The manufacturer was not made aware of the issue. And if, indeed, the transmission has failed or is showing dramatic wear in that distance, Id be asking Hyundai to help out with the cost of repairs. The sky was sunny, and the temperature was about 70 degrees. The Hyundai Santa Fe consistently ranks among the top five most reliable vehicles of its class. Now the vehicle has 16000 miles and the issue has come back. 2022 hyundai santa fe. Hyundai Questions Hyundai Santa Fe remove transfer case from 04 hyundai santa remove transfer case from 04 hyundai santa fe Share this conversation Answered in 15 minutes by: 11/3/2010 Hyundai Mechanic: Cardoctor74 Cardoctor74, ASE Certified Technician Cardoctor74 Hyundai Mechanic: Cardoctor74 Cardoctor74 Satisfied Customers Master ASE Technician See Think you have a lemon? One problem related to transfer case has been reported for the 2012 Hyundai Santa Fe. Stated this was a hazerdous waste spill and extremem safety hazzard but dealers made no other offer of help. The contact stated while driving approximately 70 mph, the vehicle started jerking. Also please check out the When we stopped for a red light, the vehicle abruptly shut down all power with no warning. Second, First time I floored the gas pedal on the highway to pass. Transmission fluid and power steering fluid could also have leaked. The vehicle was towed to the dealer where it was diagnosed that there was 1/3 amount of water in the fuel tank, causing damage to the fuel injector. 2002 & 2004 Hyundai Santa Fe transmission case defect: See the Back button blue bar at the very top of the page to explore more. The approximate failure mileage was 4,000. Stress fracture started on passenger side of front windshield. The strangest part of the issue is that after I would pull over and stop the vehicle, I would clean the sensors on outside of the car and on then restart the car and then sometimes it would work again. 2011 Hyundai Santa FE Transfer Case 2.4, AUTO, 4X4 2.4L (4 CYLINDER) Genuine Hyundai Part Excellent Condition 121K Miles 1-Year Warranty Located at Toledo, Ohio 43974 More Details $345.00 Sale Price Add To Cart Starting at $32 /mo with Affirm 4 Stock#: D322269164H 2011 Hyundai Santa FE Transfer Case 2.4, AUTO, AWD 2.4L (4 CYL) Genuine Hyundai Part The manufacturer had not been informed of the failure. Warnings appeared on the instrument panel at the same time the power steering would go out and I would not be able to safely steer the car. A blown bearing is the cause of many slipped transfer cases. In last effort lm with president of lester glenn 11/18 at 3:20pm asking to call back and resolve so I would not have to file complaint, nobody called me as of 11/19 at 1pm. Parts distribution disconnect. This could be an adventurous family SUV if the idea of an adventure is avoiding car fires, feeling every bump in the road and dealing with annoying electrical issues. I was petrified. I have 2017 Honda civic and have gearbox problem running 92000km only. I received the warning: "a possible condition with your transmission control system has been detected with your 2022 santa fe (5nms5dal4nh384740) on 10/17/2022 at 05:12 pm pdt. HYUNDAI SANTA FE VIDEO Spark Plug Change Hyundai Instructional repair video GUIDE Coolant Leak Symptoms When your car begins to leak coolant the first indicator is the engine will start run hot and possibly overheat. While driving at 25 mph, the consumer heard a screeching sound that was followed by a loud bumping noise. (5) View all. See the jurisdictions in which our lawyers are licensed, admitted, or otherwise authorized to practice. The transfer case will still try to put drive to the rear tyres if it senses front slipping at any speed. 2021 hyundai santa fe. Called closest Hyundai dealer, both dealerships said appointments were three weeks out, scheduled on 12/1 with Burns. One came off while driving 40mph the other at 75mph. We never sell what we cannot verify and we are known in the industry for putting our reputation first and not profits. The local dealer was not contacted. Are you affected? . Transfer case is failing at 61,000 mile, a lot of nose and vibration. Called dealer and dealership wanted a month to get back into service dept. The contact stated that upon the start of her vehicle while at a gas station, the vehicle initially failed to accelerate upon the depression of the accelerator pedal. When dealership was first looking at this steering issue, I reminded them of that occurrence and requested that they consider possible rodent damage to electrical system as a cause of the steering issue. Finding out what part you need can be tricky if you don't know how to identify it. In May, the company was required to pay $1.3 billion in a settlement to customers because of fire concerns from defective engines. The local dealer was not contacted. By buying a new replacement part, you can save hundreds, even thousands of dollars in costly auto repairs later down the road. Designed utilizing the latest technology, this product by SKF features premium quality and will perform better than advertised. A full system check is recommended to be done when convenient. (+ another 2500 for a new auto box). No indication of maintenance instructions in owners manual. My 2018 Kia Sportage did it instantly. View all. It now just turns off while driving. You can do this by disconnecting the wiring harness from the transfer case. If the solenoid wasnt faulty there would be no need to drain the pan or replace the gasket, so I think you have a good claim to be covered for the whole cost of the repair, including the new oil and gasket. 2013 Hyundai Santa Fe problems. The contact received notification of nhtsa campaign number: 22v746000 (power train) however, the part to do the recall repair was not yet available. I asked why not?? This same incident has taken place multiple times in the past two weeks. When I reached my destination about 20 miles further I got out and looked at the roof. On average, the cost for a Hyundai Santa Fe Transfer case fluid is low Inspection is $95 with $0 for parts and $95 for labor. The contact stated that the center console electronic gear shifter intermittently failed to operate as needed. Carsguide I was rearended in stopped position at 55+mph by a suv that pushed me forward causing front end collision with the stopped car in front of me. The manufacturer was made aware of the failure and a case was opened. The engine has had an oil leak since purchased new in 2021. What are my rights as a consumer with a 4-day old vehicle they now want back for an indeterminate time? The dealer turned the rotors; however, the contact stated that if the cruise control was activated, it would destroy the rotors. I was able to retain control of car and safely park. This is a brand new car -. This arrangement allows all four wheels to receive the same amount of power at all times, and eliminates the binding that occurs when a four wheel drive system is activated on dry pavement. This has now happened a total of 4 times in the last 4 months. 2013-2015 Hyundai Santa Fe Transfer Assembly, 2016-2018 Hyundai Santa Fe Transfer Assembly, 2009-2012 Hyundai Santa Fe Transfer Assembly, 2006-2009 Hyundai Santa Fe Transfer Assembly, 2000-2006 Hyundai Santa Fe Transfer Assembly, 2000-2006 Hyundai Santa Fe Case Assembly-Automatic Transaxle, 2006-2009 Hyundai Santa Fe Case Assembly-Automatic Transaxle, Hyundai Santa Fe Transfer Case Output Shaft Snap Ring. 2011 Hyundai Santa Fe problems. How Does the CFPBs Debt Collection Rule Affect You? . The vehicle was taken back to dealer where the driver was informed that the transmission and the rear differentials needed to be replaced. Then on 8/31, while merging onto a highway, I pressed the accelerator and although the engine revved, the car did not increase in speed. Firm ride usually means better handling. I hit the end call button to dismiss Google Assistant (using Android Auto) and it took 5 or 6 whole seconds to dismiss it. New vehicle purchased 10/15/21 from [dealer] in Toms River NJ. The first malfunction happened on 7/23. is not liable for the accuracy of any information provided in the answers. Here's what you need to know about the problem and how. It was as if the battery was disconnected. My '02 AWD GLS had such a leak at about 40,000 miles (50 k ago). Parts distribution disconnect. The other two on drivers side are still intact. How To, off-road tips and adventure travel destinations, Not just utes. Should the hyundai dealership not sell me a vehicle with a dangerous open recall on jan 11 when the campaign is opened up on 12/27/2021? Engine compartment fire- The 2019 Hyundai Santa Fe lineup has seen a few cases of engine compartment fires. . Compensation for potential legal violations, and any results obtained, depends upon the specific factual and legal circumstances of each case. This is giving me anxiety about the loss of gas in the vehicle. SPONSORED LINKS. Hyundai Santa Fe Club Message Forum: A fun, cozy site where you Discuss Purchasing, Test Drives, Reviews, Photos, Interior & Ex, Moderators:TroutGuy.hyundaisantafemessageboard, MetalMessiah78, sbr711, terri35, lovemysantafe, twospirits, Edging1, chrysande, shup, steff1965, Killer Charlie, hardydoug. 00. Click on other model year to view more problems: 2018 2019 2020 2021. Lemberg Law is a consumer law firm helping victims of bad manufacturing and run-arounds from auto companies. The repair shop contacted every hyundai dealership in the southeast region only to find out the windshields were on backorder until oct. 31st. While driving 70 mph (posted speed limit) on I-95 in north carolina in march, we had the roof tilted open. As of august 15, 2022 the vehicle had not been repaired. Steering wheel buttons for voice assistant are absolutely terrible. On delivery the vehicle pulled to the left on the highway. Upon starting the vehicle, the gear shift went into drive mode but did not engage the engine or electric motor when depressing the accelerator. -- their corrective action was as follows: -- checked ground connection for mdps. We've listed all relevant models here. We can not drive this vehicle because when it happens it is very sudden and gives no warning. I could have possibly got a used one from a breakers but I couldn't find both a transfer case and an auto box from anywhere here (doesn't seem to be that many Santy's about) and then they would have had no guarentee on them. Even though there is a 'manual' AWD button, it disengages at about 40km/hr. No appointments. Borg Warner specializes in manufacturing these transfer cases and the BW4424 is the most common. The firms main office is located at 43 Danbury Road, Wilton, Connecticut. Hyundai is recalling certain model year 2014 Santa Fe vehicles manufactured November 5, 2013, through November 15, 2013, and equipped with P235/65R17 . Triple a was made aware of the failure but was unable to jumpstart the vehicle. They stated that it is a problem with the power steering module has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? What does a rebuild kit give you? The vehicle functionality of switching from the electric hybrid mode to the engine failed, and the vehicle lost motive and electrical power. It is also does not giving approximate mileage as described by the company on the sticker. We were responsible for our 0 deductible. There are a few reports of transmission/transfer case failures, as your mechanic has told you, but it's not widespread, and with a warranty that lasts for five years with unlimited kilometres you should be well covered if something does go wrong. of a engine on a 2010 Hyundai. The contact received notification of nhtsa campaign number: 22v746000 (power train) however, the part to do the recall repair was unavailable. It was dripping and smoking right after I picked it up. They said nothings wrong and nothing showed up on the computer they plug into it. MAKE YOUR PURCHASE Other 2nd opinions believe the auto switch in the Smart system failed and left it stuck in 4wheel dr hence overheating the transfer case. The contact later discovered that the vehicle was placed under nhtsa campaign number: 22v746000 (power train) which she linked to her failure. It seemed to happen on days that there was poor weather or messy roads that would impede the sensors' abilities. If you find that there is a problem with your transfer case, then you can take it to an auto repair shop to have it fixed. I had it towed to the dealer the final time it happened. Haven't use cable yet so not sure if cable will work. If it is a leaking master cylinder, and as a result the clutch has been contaminated by the leaking fluid then you have a legitimate claim, but you won't know until the clutch can be checked. Good. He still brushed me off and I asked for corporates number so I could contact them. When my wife sits in the passenger seat the seat is so low she cannot see over the dashboard. This website is attorney advertising: prior results do not guarantee a similar outcome. The contact stated that the "transmission system error" message was displayed. I definitely agree that 60,000km is pathetically short for the lifespan of a modern transmission. Every year, auto manufacturers buy back, replace or pay cash settlements to thousands of lemon owners like you. According to hyundai customer portal, car recorded the following dtcs (diagnostic trouble codes): -- * c168886 (system: chassis; sub-system: lkas) * c240162 (system: chassis; sub-system: eps) -- after I turned car off and back on twice, warnings cleared and power steering started working again. So I took the car home and continued driving it as its my only vehicle. Hyundai Santa Fe Transmission Problems and Repair Descriptions at TrueDelta All years Santa Fe Problems o Engine (27%) Transmission (9%) Brakes (6%) Suspension (20%) Electrical and AC (25%) Body and Trim (7%) Other (5%) Select a problem area Chart based on 1669 repairs. The vehicle was then towed to (boulder Hyundai 2555 30th St, boulder, co 80301) where the vehicle was repaired under NHTSA campaign number: 17V226000 (engine and engine cooling). My family and I left on a 700 mile road trip the next morning and by that night, the engine began making a knocking noise. All of the models you list would do the job you want well, so it comes down to personal choice. It is going to the shop this week, but I really feel like I got a lemon of a vehicle! Stated this was a hazardous waste spill and extreme safety hazard but dealers made no other offer of help. Triple a towing company was not able to jumpstart the vehicle, and the vehicle was towed to the dealer. Please also check out the This is my latest issue with my 2012 Santa Fe (the previous being a bad transfer case which made it sputter, a bad 4wd coupling assembly which made it clunk while turning & a bad transmission range shaft which caused it to not start occasionally). The latest and future car tech from around the world, We're here to help you with any car issues. Crossroads hyundai of loveland inspected the vehicle were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? See They are going to keep it for a few more days to do some more diagnostic testing, but don't know what the issue is. The dealer advised the vehicle would need a new transmission. 2013-2015 Hyundai Santa Fe Transfer Assembly Part Number: 47300-3B510 Vehicle Specific Other Name: Transfer Case Your Price: $ 1225.60 Retail Price: $1663.95 You Save: $438.35 Check the fit Add to Cart Fits the following Hyundai Santa Fe Years: 2013-2015 Hyundai Santa Fe | DOHC - GDI | Wagon - Long 5Door 6P, Wagon - Long 5Door 7P View related parts Here's what to look out for and buy smart, Get to know the personalities behind the team every week, The most interesting hints of what's to come. statistics and reliability analysis of the 2012 Hyundai Santa Fe based on all problems reported for the 2012 Santa Fe. Again they brushed it off and told me theres nothing. The vehicle was then towed to (boulder Hyundai 2555 30th St, boulder, co 80301) where the vehicle was repaired under NHTSA campaign number: 17V226000 (engine and engine cooling). You can do this by making sure that there is no debris in the gears of your transmission. We called roadside assistance and tried unsuccessfully to restart the vehicle numerous times over the 2 1/2 hours while we were waiting for the tow truck. Also, the average frequency and severity of repairs is lower than other vehicles, making the Santa Fe one of the most reliable . we liked the first so much, we bought a second. The manufacturer was not made aware of the issue. The glass "eye brow" that sits in front of the moon roof was shattered. If you have a problem with the linkage, you must have a new chain installed to give a Santa Fe the stability it needs for its intended gear ratio. One NHTSA complaint shows what can happen. 2002 vehicle was inspected by the dealership when problem realized, - during warranty period, but reported no problem. You wont have to search anymore for a Hyundai transfer case online. Our certified mobile mechanics can come to you now. Sound off and share your experience with other visitors in the comment box below. I know of multiple others with the same issue including 1 family member with the same vehicle and year and multiple people on the hyunda forums. We purchased my 2022 hyundai sante fe in july of 2021. The failure mileage was approximately 11,000. Leaking appears to be coming from a while plastic block at the rear of the gas tank. On tuesday 11/01/2022, I took the vehicle to sport durst hyundai in durham, nc who informed me the engine has failed but it would not be covered under warranty because they do not deem this to be a manufacturers defect.
Springfield University Hospital Gym, Mi Compromiso Contigo Amor, Liverpool Nightclubs In The 70s, What Is The Fine For Expired Boat Registration, Soooraven Before Surgery, Articles H